Used 2000-2001 Yamaha SRX700 Snowmobile Service Manual

Description

This Used 2000-2001 Yamaha SRX700 Snowmobile Factory Service Manual Factory Service Manual provides detailed service information, step-by-step repair instruction and maintenance specifications for:

2000-2001 SRX700 Snowmobile Service Manual Table of Contents

General Information
Periodic Inspection And Adjustment
Chassis
Power Train
Engine
Cooling System
Carburetion
Electrical
Specifications

1998-1999 Yamaha SRX600 SRX700 MSRX700 Mountain SRX Snowmobile Service Manual Index of Topics

Chapter 1
General Information
Machine Identification
Frame Serial Number
Engine Serial Number
Important Information
Preparation For Removal And
Disassembly
All Replacement Parts
Gaskets, Oil Seals, And O-rings
Lock Washers/plates And Cotter Pins
Bearings And Oil Seals
Circlips
Loctite®
Special Tools:
For Tune Up
For Engine Service
For Power Train Service
For Carburetion Service
For Electrical Service

Chapter 2 Periodic Inspections And Adjustments
Introduction
Periodic Maintenance Table
Engine
Spark Plugs
Oil Pump
Fuel Line Inspection
Cooling System
Carburetor Synchronization Engine Idle Speed Adjustment
Throttle Cable Adjustment
Throttle Override System (T.O.R.S.) Check
Starter (Choke) Cable Adjustment
Yamaha Power Valve System (YPVS) Adjustment
Yamaha Power Valve System (YPVS) Pre-season Checks
Exhaust System Inspection
Power Train
Drive V-belt
Engagement Speed Check
Parking Brake Pad Inspection Parking Brake Adjustment
Brake Fluid Level Inspection
Brake Pad Inspection
Brake Hose Inspection
Air Bleeding (Hydraulic Brake System)
Drive Chain
Track Tension Adjustment
Slide Runner Inspection
Chassis
Ski/Ski Runner
Steering System
Lubrication
Electrical
Headlight Beam Adjustment
Tuning
Carburetor Tuning
Clutch
Gear Selection
High Altitude Tuning
Front Suspension
Rear Suspension

Chapter 3 Chassis
Steering
Inspection
Installation
Ski
Inspection
Front Suspension
Handling Notes
Inspection
Installation

Chapter 4 Power Train
Primary Sheave And Drive V-belt
Removal
Disassembly
Inspection
Assembly
Installation
Secondary Sheave
Disassembly
Inspection
Assembly
Installation
Drive Chain Housing
Inspection
Installation
Jackshaft
Inspection
Jackshaft And Drive Chain Housing Installation
Brake
Brake Pad Replacement
Brake Caliper And Parking Brake
Brake Caliper Disassembly
Brake Caliper Inspection
And Repair
Brake Caliper Assembly
Brake Caliper Installation
Brake Master Cylinder
Inspection
Brake Master Cylinder Assembly
Slide Rail Suspension
Srx600/600s, Srx700/700s
Msrx700p
Inspection
Front Axle And Track
Inspection
Installation

Chapter 5 Engine
Engine Assembly
Cylinder Head And Cylinder
Removal
Inspection
Installation
Oil Pump, Crankcase And Crankshaft
Inspection
Installation
CDI Magneto
Removal
Installation
Recoil Starter
Removal
Inspection
Installation
Yamaha Power Valve System (YPVS)
Removal
Inspection
Assembly
Installation

Chapter 6 Cooling System
Heat Exchanger
Inspection
Water Pump
Removal
Inspection
Installation
Outlet Water Jacket Joint
Inspection
Installation

Chapter 7
Carburetion
Carburetors
Removal
Inspection
Assembly
Fuel Level Adjustment
Installation
Fuel Pump
Inspection
Installation

Chapter 8 Electrical
Switch Inspection
Switch Inspection
Inspecting A Switch Shown In The Manual
Ignition System
Circuit Diagram
Troubleshooting
Spark Plug Cap
Ignition Coil
Cdi Magneto
Spark Plug
Throttle Override System (TORS)
Handlebar Switch (right)
Carburetor Switch
Main Switch
Lighting System
Circuit Diagram
Troubleshooting
Bulb(s)
Headlight Beam Switch
Cdi Magneto
Signal System
Circuit Diagram
Troubleshooting
Tail/brake Light Bulb
Brake Light Switch
Water Temperature Sensor
Oil Level Switch
Fuel Sender
Condenser
Grip Warmer System
Circuit Diagram
Troubleshooting
Grip And Thumb Warmer Coil
Variable Resistor
Cdi Magneto
Yamaha Power Valve System (YPVS)
Circuit Diagram
Troubleshooting
Servo Motor
CDI Magneto
Fault Location Table

Chapter 9 Specifications
General Specifications
Maintenance Specifications
Engine
Power Train
Chassis
Electrical
General Torque Specifications
Definition Of Units
Cable Routing